14 December 2007

A Condensing Boiler for Hot Water


After a lot of research into different methods for obtaining domestic hot water, suitable for our home, we decided on a condensing gas boiler. In Barcelona, where we don’t have access to an alternative energy source (yet?), we concluded gas would be the most efficient way to heat the water for our shower, kitchen and central heating. The condensing boilers are especially environmentally friendly because of their efficient use of the gas and their considerably lower CO2 (responsible for global warming) and Nox (responsible for acid rain) emissions. We needed a combi-boiler in order for it to provide hot water for central heating as well as domestic hot water all year round.

In the wall-mounted boiler Cerasmart by the German brand Junkers, widely available in Spain, we found what we were looking for. The advantages: gas saving and low emissions.

How does it work?


The condensing boilers recycle the energy that is normally lost through the duct into the atmosphere. It catches the water vapour produced by the burning of gas for it to condense back into water. This way the heat, produced as water vapour, is recovered and the boiler uses less gas. Image by Junkers

“Typical condensing boiler efficiencies are around 90%, which brings most brands of condensing gas boiler in to the highest categories for energy efficiency. Condensing boiler manufacturers claim that up to 98% thermal efficiency of fuel conversion can be achieved in normal domestic use, compared to 70%-80% with a conventional design." (Via Wikipedia) Junkers claim the boiler Cerasmart to be 21% more efficient than standard ones, due to the fact that it can work at lower temperatures.

Condensing boilers are especially recommended if you have under-floor heating, low H2O radiators (like us) or other energy saving heating solutions.

A slight drawback is that you need to install an extra draining pipe to get rid of the condensate. This can either be installed vertically through the roof, or diagonally through the wall to the outside. (see photo on the right)

Another disadvantage might be the fact that condensing boilers are generally more expensive than conventional ones. It is estimated that “as of 2006, at UK prices the extra cost of installing a condensing boiler should be recovered in around 2-3 years” (via Wikipedia).

The Cerasmart boiler, for a 4-people flat with central heating by Junkers will cost you around 2268€ in Barcelona (you might be able to get a standard one for under 1800€). We bought ours at Tuysa.

Why we didn’t go solar.

Solar Hot Water Panels
would have been the most eco-efficient solution, but all the companies we contacted turned us off the idea. Technically, so they say after visiting our flat and roof, it would be very difficult due to the distance (2 floors) the water would have to travel to and from the roof. Plus we would have to give up 2 of our precious 58 m2 to make space for a not so beautiful water tank.

The initial first cost didn’t help make our decision easier as it would have been at the very least 2000€ for the panels to which we would have to add the installation cost and a back-up boiler. Moreover, we would have to get the approval of the fellow property owners of our building to install the solar panels on the communal roof. This shows again that eco-renovating a flat within the city is a very different story to building an eco house in the countryside where space and neighbours are less of an issue.

8 comments:

riemann said...

Ok, I understand why you didn't go solar water heating, but why not electric?
I'm currently switching from condensing boiler to electric for domestic water heating (flat would be still heated by condensing boiler). I believe that electric instantaneous water heater is better because of:
- zero emission on local level (only on power plant level and only if it's not nuclear/wind/solar)
- short way from heat source, so less water waist, and less heat loss (to warm up pipe)

Anonymous said...

I guess they didnt choose to go electric cause of the cost. Gas is cheaper. Otherwise there would be no question how to build any heating system, everyone would go electric as its elegant solution.

Kombi Servisi said...

nice post thanks

BISINEER INDIA said...

Fantastic and useful weblog. Thanks for publishing this. It’s useful and informative. Keep up the great.
Gas Boiler Manufacturers

Irene maranto said...

The whole information that you provide is really useful and great and also the collection and facts are absolutely great to see.
plumbing company blackpool

Olivia@ boiler repair said...

I am gonna ask the same question regarding electric.

brittni meghan said...

Today condensing boiler is one of the most favorite boiler in boiler industry.It's only because of it's easiness of use,it's also cheapest than other boiler.This kind of boiler installation is very much helpful for our house.

Paul Whitehouse said...

Condensing Boilers are fab - except when they have a problem! In fact, when my broken central heating boiler decided to break I was really worried about the cost of getting it fixed!

I heard that it's a good idea to get quotes, but after the prices I was getting plus some firms and they were very expensive! Then I was on google and I found a local firm (I'm from Chester) called STL Heating. I wasn't sure if they'd be expensive - but I went on the review page and they looked really good - so I called them up and they were really helpful. They said they could come out and fix my boiler the very next day, and the price they charged was a lot less than I expected too! So I thought "that'll do for me please!" and I've got them to come out and fix my boiler!